Product Overview
Bio Based Lift Station Solvent Degreaser - SI58LT5.
Is a soy-based solvent degreaser non-emulsifying product with a slightly citrus aroma that floats on the surface of wastewater removing heavy grease deposited on the surface and the walls creating and odor barrier. Floating degreaser keeps pumps, hoses and walls clean and functioning properly. Use approximately 1/2 gallon of lift station degreaser for every square foot of wastewater surface area. Floating lift station degreaser removes most sewer odors and gases caused by vertical buildup of grease, fat, sewage and soap.
Derived from natural oils, vegetables and/or plant matter and do not contain toxic chemicals.
- USDA Certified Biobased Product
- Reduce Costs / Does Not Evaporate
- Odor inhibitor / floats on the surface of wastewater
- Twice as Strong as Mineral Spirit
- Non-Flammable
- Non-Hazardous, Will not interfere with lift station bacteria.
SAFETY DATA SHEET
SECTION 1 – IDENTIFICATION
TRADE NAME: Lift Station Degreaser with Citrus Aroma, PRODUCT NUMBER: SI-58LT55, SUPPIELD: Royac, Inc. 12514 Willow Breeze Dr. Tomball, TX 77377 RECOMMENDED USE: Substitute of Petrochemical Based Solvent.
SECTION 2 – HAZARD IDENTIFICATION *** EMERGENCY OVERVIEW ***: No Information
GHS Classification
Symbol(s) of Product
No GHS Symbols Exist
Signal Word
No Signal Word has been assigned
SECTION 3 – COMPOSITION / INFORMATION ON INGREDIENTS
Chemical Name CAS-No. Wt. % GHS Symbols GHS Statements - No hazardous items exist
The text for GHS Hazard Statements shown above (if any) is given in the "Other information" Section.
SECTION 4 – FIRST AID MEASURES, EYES CONTACT: Flush with large amount of water for at least 15 minutes, SKIN CONTACT: Rinse with soap and water, INGESTION: If ingestion of large amount does occur, seek medical attention. Do not induce vomiting
SECTION 5 – FIRE FIGHTING MEASURES, UNUSUAL FIRE AND EXPLOSION HAZARDS: No Information.
SPECIAL FIRE FIGHTING PROCEDURE: As in any fire, wear self-contained breathing apparatus pressure-demand (MSHA/NIOSH approved or equivalent) and full protective gear. Water spray to cool containers or protect personnel. Use with caution. Water runoff can cause environmental damage. Dike and collect water used to fight fire. EXTINGUISHING MEDIA: Carbon Dioxide, Dry Chemical, Foam, Water Fog
SECTION 6 – ACCIDENTAL RELEASE MEASURES SPILL AND LEAK PROCEDURES: Contain or isolate spill or leak area immediately. Transfer to secure containers. Where necessary, collect using absorbent material. Prevent entry into waterway, sewer, or basements or confined areas, SURFACE MAY BECOME SLIPPERY AFTER SPILLAGE.
SECTION 7 – HANDLING AND STORAGE HANDLING PROCEDURES: Wash thoroughly after handling. As with all chemicals, good industrial hygiene practices should be followed when handling this material, STORAGE PROCEDURE: Storage in a dry well-ventilated area. Do not handle or store near an open flame, heat or other sources of ignition.
SECTION 8 – EXPOSURE CONTROL & PERSONAL PROTECTION Ingredients with Occupational Exposure Limits.
Chemical Name ACGIH TLV-TWA ACGIH-TLV STEL OSHA PEL-TWA OSHA PEL-CEILING
No hazardous items exist
Personal Protection
RESPIRATORY PROTECTION: NIOSH/MSHA approved respirators may be necessary if airborne concentrations are expected to exceed exposure limits.
SKIN PROTECTION: Wear impervious gloves to prevent contact with the skin.
EYE PROTECTION: Wear safety glasses with side shields (or goggles) and a face shield.
OTHER PROTECTIVE EQUIPMENT: Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower.
HYGENIC PRACTICES: Wash thoroughly after handling. Wash hands before eating. Remove contaminated clothing
and wash before reuse. Avoid breathing vapors. Do not eat, drink, or smoke in areas where this material is used.
SECTION 9 – PHYSICAL & CHEMICAL PROPERTIES
Appearance: Pale yellow liquid Physical State: Liquid
Odor: Typical Odor Threshold: Citrus Aroma
Density, g/cm3: 0.879 pH: N.D.
Freeze Point, °F: N.D. Viscosity: N.D.
Solubility in Water: Insoluble Explosive Limits, vol%: N.D.
Boiling Range, °F: 392 - 392 Flash Point, °F: >200
Evaporation Rate: <1 Auto-ignition Temp., °F: N.D.
Vapor Density: >1 Vapor Pressure: N.D.
VOC 1 g/l
SECTION 10 – STABILITY & REACTIVITY
STABILITY: No Information
CONDITIONS TO AVOID: Avoid excess heat and sources of ignition.
INCOMPATIBILITY: Prevent contact with strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: During combustion carbon dioxide may be formed. During combustion carbon monoxide may be formed.
HAZARDOUS POLYMERIZATION: No Information
SECTION 11 – TOXICOLOGICAL INFORMATION
EFFECTS OF OVEREXPOSURE - INHALATION: Low order of toxicity.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT: May cause skin irritation.
EFFECTS OF OVEREXPOSURE - EYE CONTACT: Contact with the eye may cause moderate irritation.
EFFECTS OF OVEREXPOSURE - INGESTION: Expected to be a low ingestion hazard.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS: No Information
Primary Route(s) of Entry: Eye Contact, Skin Contact
Acute Toxicity Values
The acute effects of this product have not been tested. Data on individual components are tabulated below:
CAS-No. Name according to EEC Oral LD50, mg/kg Dermal LD50, mg/kg Vapor LC50, mg/L
No
hazardous
items exist
SECTION 12 - ECOLOGICAL INFORMATION No Information
SECTION 13 – DISPOSAL CONSIDERATIONS DISPOSAL INSTRUCTIONS: Treatment, storage, transportation and disposal must be in accordance with applicable Federal, State and Local regulations. Regulations may vary in different locations. Characterization and compliance with applicable laws are the responsibility solely of the generator.
SECTION 14 – TRANSPORT INFORMATION UN NUMBER: N/A, Not regulated, UN PROPER SHIPPING NAME: Not regulated, SHIPPING CLASSIFICATION: 55,
SECTION 15 – REGULATORY INFORMATION
U.S. Federal Regulations:
CERCLA - SARA Hazard Category
This product has been reviewed according to the EPA ‘Hazard Categories’ promulgated under Sections 311 and 312 of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to meet the following categories:
None Known
SARA SECTION 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
No Sara 313 components exist in this product.
TOXIC SUBSTANCES CONTROL ACT:
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States: No TSCA components exist in this product.
U.S. State Regulations:
NEW JERSEY RIGHT-TO-KNOW: The following materials are non-hazardous, but are among the top five components in this product.
Chemical Name
Methyl esters CAS-No. 67762-38-3, Citrus Oil - CAS No. 94266-47-4
PENNSYLVANIA RIGHT-TO-KNOW
The following non-hazardous ingredients are present in the product are at or greater than 3%.
Chemical Name CAS-No.
Methyl esters 67762-38-3
CALIFORNIA PROPOSITION 65
Proposition 65 chemicals are not expected to be found in this product above those naturally present in their agricultural source.
Proposition 65 exempts naturally occurring chemicals from an obligation to label.
International Regulations: As follows -
CANADIAN WHMIS:
This MSDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16 headings.
WHMIS Class: No Information
SECTION 16 - OTHER INFORMATION
Revision Date: 11/4/2014 Supersedes Date: New SDS Datasheet produced by: EH&S - Regulatory Department
HMIS Ratings:
Health: 1 , Flammability: 1, Reactivity: 0, Personal Protection: X
DISCLAIMER: THE VOLATILE ORGANIC COMPOUND (VOC) CONTENT REPORTED HEREIN, IF ANY, IS BASED ON A MATERIAL VOC
CALCULATION. NOTE THAT SEVERAL METHODS ARE USED FOR CALCULATING VOC CONTENT AND THAT STANDARDS/
REQUIREMENTS REGARDING VOC CONTENT VARY BY LOCATION/JURISDICTION. ACCORDINGLY, SSI MAKES NO
REPRESENTATIONS OR WARRANTIES, EXPRESS OR IMPLIED, REGARDING THIS MATERIAL’S COMPLIANCE WITH VOC STANDARDS/
REQUIREMENTS APPLICABLE IN LOCATIONS/JURISDICTIONS WHERE THIS MATERIAL MAY BE SOLD OR USED.
Icons for GHS Pictograms shown in Section 3 describing each ingredient:
No GHS Pictograms exist for Section 3
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined, N.I. - No Information
The information on this SDS was obtained from sources which we believe to be reliable. However, the information provided is
without any warranty, expressed or implied, regarding its correctness. Some information presented and conclusions drawn herein
are from sources other than direct test data on the product itself. The information and recommendations are offered for the user's
consideration and examination and should be used to make an independent determination of the methods to safeguard workers and
the environment. The conditions or methods of handling, storage, use and disposal of the product are beyond our control and may
be beyond our knowledge. For these reasons we do not assume responsibility and expressly disclaim any liability for loss, damage,
or expense arising out of or in any way connected with handling, storage, use, or disposal of this product. If the product is used as a
component in another product, this SDS may not be applicable. It is the responsibility of the user to comply with all Federal, State,
and Local laws and regulations.
